全自動自上料攪拌車進行水泥操作的流程

 來源:http://www.evildooinz.com 日期:2021-06-07 發布人:admin
1、水泥出料前,攪拌筒應以10~12rpm的轉速旋轉1分鐘后出料。
1. Before cement discharging, the mixing drum should rotate at 10-12rpm for 1 minute before discharging.
2、卸料后,應立即用車上的軟管沖洗入口、卸料漏斗和卸料槽,將附著在車體上的污垢和殘余混凝土排出,然后向攪拌筒內注水。回程時,攪拌筒應緩慢轉動,清理內壁,以免殘留的爐渣附著在筒壁上,攪拌葉片在一次裝料前將水排干。
2. After discharging, the hose on the truck shall be used to flush the inlet, discharge funnel and discharge tank immediately to discharge the dirt and residual concrete attached to the truck body, and then inject water into the mixing drum. When returning, the mixing drum should rotate slowly to clean the inner wall, so as to avoid the residual slag adhering to the drum wall, and the mixing blade will drain the water before the primary charging.
3、運輸水泥時,發動機轉速在1000-1400轉/分范圍內,使發動機產生扭矩,轉速不超過40公里/小時
全自動自上料攪拌車
3. When the cement mixer transports cement, the engine speed is in the range of 1000-1400 rpm, so that the engine produces torque, and the speed is not more than 40 km / h
4、水泥攪拌運輸車完工后,應對攪拌筒內部和筒體進行清理,不得將剩余混凝土留在攪拌筒內。
4. After the completion of the cement mixer truck, the inside and cylinder of the mixing drum shall be cleaned, and the remaining concrete shall not be left in the mixing drum.
5、水泵工作時,嚴禁空轉,連續使用時間不得超過15分鐘。
5. When the water pump of cement mixing truck is working, it is strictly forbidden to idle, and the continuous use time shall not exceed 15 minutes.
6、水箱的水量應始終處于滿水狀態,以備緊急使用。冬季停機后,應將水箱、水泵、水管、攪拌桶內的水排干,并將水貯存在朝陽無水的地方,以免凍傷機器。
6. The water volume of the water tank of the cement mixer truck should always be full for emergency use. After shutdown in winter, the water in the water tank, water pump, water pipe and mixing bucket shall be drained, and the water shall be stored in the place without water in Chaoyang to avoid frostbite.
7、冬季攪拌車應及時安裝保溫套管,并用防凍劑保護攪拌機。燃油標簽應根據天氣變化進行更換,以保證機器的正常使用。
7. In winter, the mixer should be installed with insulating sleeve in time, and the mixer should be protected with antifreeze. The fuel label should be replaced according to the weather change to ensure the normal use of the machine.
8、泥攪拌運輸車液力傳動部分檢修時,發動機、液壓泵應無壓運轉。
8. When the hydraulic transmission part of cement mixer truck is overhauled, the engine and hydraulic pump should run without pressure.